Volkszone Forum banner
fuel pump
1-20 of 29 Results
  1. Aircooled Mechanical Tech
    I have been looking at an issue regarding no fuel getting to the twin carbs. I thought it was just the fuel pump needing to be replaced so bought another mechanical one. Anyway still nothing. So now got the wife to manually crank the engine for me to put my finger on the push rod and there is...
  2. Aircooled Mechanical Tech
    My mechanical fuelpump had broken down and put loads of rusty looking fuel in the carb float chambers as well as into the engine case, I'm on with changing the oil and ive fit an electric fuel pump I had which is to feed twin webber 34ict carbs. Unfortunately the Chinese jk versions but as long...
  3. Aircooled Mechanical Tech
    Hi, I have a 1970 Basic 1200 Beetle and it's not running like it should. I've had it on the road for a month or so and no problems until now. I am getting some bad juddering when I accelerate. It happens especially in 2nd, but if it does also happen at higher speeds. I have checked the spark...
  4. Aircooled Mechanical Tech
    I'm replacing the fuel pump on a 78 bay type 4 engine. Found that the top bolt was a nightmare to get access to and took off the top part of the pump to give me a bit of clearance to use an alley key. Now want to put back just by bolting on the whole pump but my alley key is too fat for the top...
  5. Items Wanted - AUTO
    Looking for an original mechanical fuel pump for a 2ltr 78 bay. Must have the two bolts on the side as it's pretty tight under the starter.
  6. Aircooled Mechanical Tech
    Where should this missing hose go off to as having running issues and this could be causing it :( 78 bay 2ltr twin carb camper
  7. Aircooled Mechanical Tech
    So I finally got round to replacing the broken fuel pump pedestal in my bug. Part of the lower section was broken off and stuck inside, managed to remove this. however there appears to be a couple of small pieces left inside. Could anybody suggest the best way to remove these? I was thinking...
  8. Aircooled Mechanical Tech
    Hi, I have a 68' Beetle with a stock 1641 twinport engine, I've just brought some 36mm twin dellorto's/manifolds/linkage and after reading quite a few threads and forums I'm still not sure what fuel pump setup to run. Ironically my old solex carb and mechanical pump setup died the day the...
  9. Aircooled Mechanical Tech
    1973 1300 wizard beetle, 1600cc unleaded conversion, 2 twin solex 40mm carbs, 4 tip Monza exhaust. Right so I think the static timing is set properly, we emptied the little carb fuel filter bottle, filled it up with some fresh juice, then squirted some easy start in the carbs, fired her up, runs...
  10. Items For Sale - AUTO
    All items now SOLD. Have some stuff for sale, as trying to get together more money to finish off my turbo engine :incheek:. First up, Holley Red fuel pump. Ideal for cars running twin carbs. Much much better than the solenoid operated facet cubes! Bought in mistake, no good for a turbo system...
  11. Aircooled Mechanical Tech
    Hi everyone it's a 85 mexibug with a 1200 engine. my old vw pump has been leaking so I order one machine7 (a repro one:rolleyes:) the problem lever stick out far, I have tried to bolt it up but it just starts breaking the pedestal any help would be greatly appreciated martin
  12. Aircooled Mechanical Tech
    I do top end rebuilt on my 1200, I have the fuel pump removed is there any way I can test the pump is not leaking as my oil smell faintly of petrol. my oil level not risen but the amount leaks it's has Iam not surprising also is it possible to rebuilt these pumps thanks martin
  13. Aircooled Mechanical Tech
    ..As above, replacing my 108mm fuel pump pushrod but noticed the old one appears to have been shortened, maybe for the kadrons (I have read psi needs to be lower, around 2ish?) pic below, your thoughts? Is it just worn? Also, in summer 2010's VolksWorld it does a nice wright up on adjusting...
  14. Chat/Discussion
    Hi ive just started to work on getting my bus back on the road after 6 years in the shed. I belive the reason it wont start is because of the fuel pump the pump has + and - wires coming out of it, so im guessing it has to be powered to work. i have taken out the pump and connected it directly...
  15. Aircooled Mechanical Tech
    Ive just taken my engine off of the gear box, and stripped it down (anciliaries) as i plan on getting a recon engine in exchange. I want to get a new fuel pump. Looking at VW websites i need to buy the correct pump (dynamo/alternator). M engine is a 1600cc (73 bay window) it has a dynamo...
  16. Items Wanted - AUTO
    Hi folks, Does anyone have a mechanical fuel pump from a type 4 engine. My van is a 73 Westy LHD. At present have an electric Facet fuel pump. Really after an original stock mechanical pump. Matt
  17. Items Wanted - AUTO
    Hi all, As my engine rebuild has taken a few twists and turns I will now be needing an electric fuel pump and pressure regulator. What ya got? Cheers, Paul.
  18. Aircooled Mechanical Tech
    How neccessary is a fuel filter between the fuel pump and carb?
  19. Aircooled Mechanical Tech
    I have installed a CB Performance Fuel Pump to my Bug and wired as recommended by the info. The pump will not stop pumping, is there something I have installed wrong, or is the pump faulty? The only difference to installation is that I put it at the side of the fuel tank with new heavy guage...
  20. Aircooled Mechanical Tech
    Hi folks, Got a prob. Newly built 1584cc TP engine. Stock parts where possible, largely used but good, nothing fancy. Got 150 miles on it and then the fuel supply failed. Turns out the fuel pump pushrod has bent and snapped. The lower half of the (new repro) fuel pedestal has disintegrated and...
1-20 of 29 Results
Top